According to eLearn MANUAL GEARBOX Synthetic oil TUTELA CAR MATRYX SAE 75W-85 - API GL-4 2.4 litres 2.08 kg 1.9 JTD 8V / 1.9 JTD 16V Manual Gearbox NOTE! I'm led to believe that the only way to check oil level on this gearbox is to drain and refill because unlike older style Fiat gearboxes this GM box does not have a level inspection access plug. Jul 20, 2020. #4. Keano said: Changed the gearbox/diff oil yesterday and found it only had 1 Litre in The manual says 1.65 but I managed to syringe the whole two litres in and and it was just 15mm below the filler hole. So get a syringe from ebay and get some fresh oil in!!! Syringe available here: Gearbox oil and transmission oil for FIAT Bravo II Hatchback (198) (85 KW / 115 PS from 2008 ) from top manufacturers of auto parts online at bargain prices on Bestpartstore.co.uk! Pump has 5 screes, 4 holding it, 1 for oil bleed. Accessed the screws from under the car and driver side wheel place (took wheel off). Took the pump down. The connector for the pump is on the left side as you look at the selespeed oil tank, disconnect it. Also there you can see the relay of the selespeed pump. Jun 17, 2013. #12. Sorry that I made it sound like that. I was going to get 5w-40 but on there chart of oils for cars on both 1.4 turbo and the 1.6 turbo it said 0w-40 when the other engine sizes said 5w-40 that's why I question the man at the counter. To change the gear oil, warm the car up by driving around a bit, as the oil will run better and get the car level. On the back of the gearbox, at the lowest point is a drain plug. Half way up the on the front is a filler plug. Drain out and refit the drain. kM8F. Free car repair guides. Illustrated step-by-step manuals and video tutorials on replacing VW UP Gearbox Oil and Transmission Oil will tell you how to carry out DIY replacement of parts and maintenance of your car quickly and cheaply. Jun 3, 2012. #8. I have a 09 T-Jet 120, and recently had the gearbox fixed. It made a loud whinning noise in 5th and 6th gear, so they changed some bearings on the high gear axle (at least that what they told me). It fixed the issue and it's running fine now. All gearboxes have oil of some description. Back in the 80s/early 90s most Fiat manual boxes used ZC90 oil and recommended it was replace every 36K miles. Later years/gearboxes used more synthetic based oils and oil change periods increased to 70K plus miles. Automatic, Selespeed, Daulogic, etc boxes have different oils/requirements. Has anyone had any problems with the bravo gearbox. My gearbox has gone again (2nd time), it will go in every gear apart fom 4th. anyone else have the same Third, to properly flush the gearbox, use one of the new gear lubricants, or a light viscosity of R&O compressor/turbine oil, filling to one-third the recommended operating oil level. Circulate under no-load conditions for 15 minutes and drain. Fig. 3: Maintenance manager taking temperature readings.

fiat bravo gearbox oil change